Product Name: 1,2-Propanediol didecanoate
Synonyms: Propylene glycol didecanoate, Decanoic acid, 1,2-propanediol ester
CAS Number: 1330-78-5
Product Use: Emollient in cosmetics, industrial solvent
Manufacturer: [Company Name]
Emergency Contact: [Emergency Phone Number, Available 24/7]
Supplier Address: [Company Address and Contact Information]
GHS Classification: Not classified as hazardous according to GHS
Signal Word: None
Pictograms: None required
Routes of Exposure: Skin, eyes, inhalation, ingestion
Hazard Statements: May cause mild skin irritation after long contact, may cause mild eye irritation, swallowing large quantities could cause discomfort
Precautionary Statements: Avoid contact with eyes and prolonged skin contact, wash hands thoroughly after handling
Potential Health Effects: Eye irritation, mild digestive upset, minimal respiratory effects expected
Chemical Name: 1,2-Propanediol didecanoate
Common Name: Propylene glycol didecanoate
CAS Number: 1330-78-5
Percentage: >98%
Impurities/Additives: Trace levels of decanoic acid and propylene glycol
Inhalation: Move person to fresh air, obtain medical advice if symptoms develop
Skin Contact: Remove contaminated clothing, wash affected area with soap and water, consult a physician if irritation persists
Eye Contact: Rinse eyes gently with water for at least 15 minutes, remove contact lenses, seek medical attention if irritation continues
Ingestion: Rinse mouth, do not induce vomiting, give water to dilute, consult physician if symptoms occur
Notes for Medical Personnel: Symptomatic treatment, no known specific antidote
Suitable Extinguishing Media: Foam, dry chemical, carbon dioxide, water spray
Unsuitable Extinguishing Media: Direct water jet can spread burning liquid
Hazards from Combustion: Carbon oxides (CO, CO2), smoke, and irritating fumes
Protective Equipment for Firefighters: Full protective clothing, self-contained breathing apparatus
Firefighting Instructions: Cool containers with water, keep away from runoff, evacuate downwind areas if needed
Personal Precautions: Wear gloves, safety goggles, avoid inhalation of vapors
Environmental Precautions: Prevent spill from entering drains, soil, and water sources
Methods for Cleanup: Absorb with sand or inert absorbent, scoop up material, place in labeled containers, ventilate spill area
Disposal of Collected Material: Treat as chemical waste, consult regulatory requirements
Spill Response: Clean area with detergent, avoid high-pressure rinsing
Safe Handling: Avoid skin and eye contact, use only in well-ventilated areas, do not ingest, ensure employees are trained for chemical handling
Storage Conditions: Store in tightly closed containers, keep in cool, dry, well-ventilated space, protect from direct sunlight and incompatible materials
Incompatible Materials: Strong oxidizing agents, acids
Advice on General Occupational Hygiene: Do not eat, drink or smoke in work areas, wash hands after use
Exposure Limits: No occupational exposure limits established for this substance
Engineering Controls: Provide local exhaust ventilation if vapors are generated
Personal Protective Equipment: Protective gloves (nitrile recommended), safety glasses, lab coat or coveralls
Respiratory Protection: Use an approved respirator if vapor forms or exposure limits are exceeded
Environmental Controls: Prevent from spreading into the environment, monitor air quality if large quantities handled
Appearance: Clear to pale yellow oily liquid
Odor: Mild, fatty odor
pH: Not applicable (not water soluble)
Melting Point: -2°C
Boiling Point: Approx. 325°C
Flash Point: >170°C (closed cup)
Evaporation Rate: Negligible
Flammability: Not highly flammable, but can burn
Vapor Pressure: <1 mmHg (25°C)
Solubility: Insoluble in water, soluble in alcohols and organic solvents
Viscosity: Medium
Density: 0.95–0.98 g/cm3 (25°C)
Chemical Stability: Stable under typical storage and handling conditions
Possibility of Hazardous Reactions: May react with strong oxidizing agents, excessive heat generates decomposition products
Conditions to Avoid: High temperatures, direct sunlight, open flames
Incompatible Materials: Strong acids, peroxides, chlorine
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, irritating organic fumes
Acute Toxicity: Low, oral LD50 (rat) >5000 mg/kg
Skin Corrosion/Irritation: May cause mild irritation with prolonged exposure
Eye Damage/Irritation: Mild, reversible irritation possible
Respiratory Effects: Not expected under normal use
Sensitization: Not expected to cause sensitization
Chronic Toxicity: Not known to be carcinogenic, mutagenic, or reproductive toxicant
Medical Conditions Aggravated by Exposure: Pre-existing skin conditions may worsen
Ecotoxicity: Low aquatic toxicity, not expected to bioaccumulate
Aquatic Organism Impact: LC50 (fish, 96h): >100 mg/L
Persistence/Degradability: Readily biodegradable in soil and water
Bioaccumulation Potential: Low, log Kow <4
Mobility in Soil: Not mobile, binds to organic material
Other Adverse Effects: None documented under standard use conditions
Disposal Methods: Incinerate in suitable facility, follow local, regional, national, and international regulations
Container Handling: Triple rinse containers, puncture and send to approved landfill or recycle
Unclean Packaging: Dispose of in line with chemical waste guidelines
Disposal Advice: Do not release into sewers or water systems
Waste Codes: Check with local waste disposal authorities
UN Number: Not regulated for transport under ADR, IMDG, DOT, or IATA
Proper Shipping Name: Not classified as dangerous goods
Transport Hazard Classes: Not regulated
Packing Group: Not assigned
Environmental Hazards: No specific hazards during transport
Special Precautions: Keep containers securely closed, avoid extremes of heat and rough handling
TSCA Status: Listed
EINECS/ELINCS Number: 215-537-3
REACH Registration: Exempt (polymeric substance or natural mixture)
OSHA Status: Not hazardous
WHMIS Classification (Canada): Not controlled
Other Relevant Regulations: Check national inventories for compliance
Labeling Requirements: Standard chemical labeling for non-hazardous substances
Providing high-quality chemical products and logistics solutions for global trade partners.
